平安操作是小型混凝土攪拌車完成其工作任務的基本保證，也是小型混凝土攪拌車操作、維修和周圍施工人員人身平安的可靠保證。下面來講講內容。

Safe operation is the basic guarantee for small concrete mixers to complete their work tasks, and it is also a reliable guarantee for the operation and maintenance of small concrete mixers and the personal safety of surrounding construction personnel. Now let's talk about the content.

1、檢查

1. Check

車身是否堆放雜物，著重檢查柴油、機油、各種齒輪油、各種助力油、發動機冷凝液和制動液，的液位和滲漏情況。

Check whether there are sundries stacked on the vehicle body. Focus on checking the liquid level and leakage of diesel, engine oil, various gear oils, various booster oils, engine condensate and brake fluid.

2、運輸

2. Transportation

在運輸途中，小型混凝土攪拌車應保持3-6轉、分的慢速運轉。在正常攪拌行駛時，高時速不得超過50km/h。在轉彎時不要太急，同時轉彎速度不大于15km/h，否則會有翻車危險。

During the transportation, the small concrete mixer shall operate at a slow speed of 3-6 rpm. During normal mixing driving, the high speed shall not exceed 50km/h. Don't turn too fast, and the turning speed is not more than 15km/h, otherwise there will be a danger of rollover.

空車時速不得超過60km/h。當塌落度損失過大時，可在符合混凝土設計配合比例要求的條件下適量加水，此項工作須由試驗室技術人員完成。除此之外，嚴禁往攪拌罐內加水。

The empty speed shall not exceed 60km/h. When the slump loss is too large, the appropriate amount of water can be added under the condition of meeting the requirements of the design mix proportion of concrete. This work must be completed by the laboratory technicians. In addition, it is strictly prohibited to add water to the mixing tank.

3、卸料

3. Unloading

混凝土運送到現場后，由工地負責人依次進行卸料，卸料要干凈，避免浪費，要及時清洗小型混凝土攪拌車罐內，排盡積水。

After the concrete is transported to the site, the person in charge of the construction site shall unload the concrete in turn. The unloading shall be clean to avoid waste. The tank of small concrete mixer shall be cleaned in time to drain the accumulated water.

駕駛員應對小型混凝土攪拌車經常進行保養，以保證攪拌罐車的使用壽命，以及正常工作。每周應該給托輪油咀加注一次高壓油脂，每班給托輪軌道加一點含石墨或硫化鉬潤滑脂。每周潤滑一次油泵傳動軸

The driver shall maintain the small concrete mixer frequently to ensure the service life and normal operation of the mixing tank truck. The supporting wheel oil nozzle shall be filled with high-pressure grease once a week, and the supporting wheel track shall be filled with a little graphite or molybdenum sulfide grease every shift. Lubricate the oil pump drive shaft once a week

小型混凝土攪拌車的平安操作注意事項就從三點來分析講解了，您對此有什么認識就來我們網站http://www.yexingrack.com進行咨詢吧！

Precautions for safe operation of small concrete mixer are analyzed and explained from three points. Please come to our website for your understanding http://www.yexingrack.com Consult!